您的位置:首页 > 新闻动态 > 地坪知识

能够确保环氧地坪漆质量的五个施工要点

发布日期:2019-06-24 浏览次数:7

环氧地坪漆质量问题,80%以上都是施工技术上出现问题,因此,在进行环氧地坪漆施工时一定要严格把好关,每一道涂层都要注重质量,只有把好质量关,才能做出优质的环氧地坪工程。环氧地坪漆施工工艺说难很难、说简单也很简单,只要掌握好五个要点,就能保证地坪漆的施工质量,做出让客户满意的环氧地坪漆工程。下面就给大家介绍环氧地坪漆施工过程中的五个要点:

More than 80% of the quality problems of epoxy floor paint are in construction technology. Therefore, we must strictly control the construction of epoxy floor paint. Every coating should pay attention to quality. Only if the quality of epoxy floor paint is well controlled, can we make high-quality epoxy floor project. The construction technology of epoxy floor paint is difficult, simple and simple. As long as five points are mastered well, the construction quality of epoxy floor paint can be guaranteed and the project of epoxy floor paint satisfying customers can be made. Here are five key points in the construction of epoxy floor paint.

环氧地坪施工

Epoxy Floor Construction

1、基础地面处理:做好基础地面的处理工作是做出优质环氧地坪漆工程的前提,环氧地坪漆施工要求基础地面强度要求不低于C25,地面平整度一般要求在2m范围内落差不大于2mm,如地下水位较高则混凝土底层应作好防水处理,含水率不高于8%,没有油污等杂物。处理完毕后,检查基底的质量,避免质量效果不佳,而导致环氧地坪漆涂装效果不佳。

1. Foundation ground treatment: good treatment of foundation ground is the premise of making high-quality epoxy floor paint project. The construction of epoxy floor paint requires that the strength of foundation ground should not be lower than C25, and the ground roughness should generally be less than 2m m in the range of 2m. If the groundwater level is high, the concrete bottom should be waterproof, with water content not higher than 8%, and no oil pollution and other impurities. After treatment, the quality of the base is checked to avoid poor quality effect, which leads to poor coating effect of epoxy floor paint.

2、环氧地坪漆材料的质量:必须选择正规地坪漆厂家生产的有质量保障的材料,所有进场材料都要进行检查,杜绝不合格产品的使用。材料使用时必须按照使用说明严格按照配比进行调配,充分搅拌均匀。

2. Quality of Epoxy Floor Paint Material: Material with quality assurance produced by regular flooring paint manufacturers must be selected. All entrance materials should be inspected to prevent the use of substandard products. Material must be used in accordance with the instructions strictly in accordance with the proportion of mixing, fully mixing evenly.

地坪漆施工

Construction of Floor Paint

3、施工工具的选择:环氧地坪漆施工时所用的施工工具如:辊筒、刮刀、漆刷、美纹纸等必须选择优质的产品,避免因地坪施工工具不良所导致的质量问题。

3. Selection of construction tools: The construction tools used in the construction of epoxy floor paint, such as roller, scraper, paint brush, paper and so on, must select high-quality products to avoid the quality problems caused by poor floor construction tools.

4、施工人员技术:要选择经验丰富的施工技术人员,施工人员应熟悉掌握本施工工艺的各项技术指标及施工方法,绝对不允许盲目施工、野蛮操作,特别是面漆施工时,一定要有三年以上工作经验的。

4. Construction technicians: To select experienced construction technicians, construction personnel should be familiar with the technical indicators and construction methods of the construction technology, and absolutely not allow blind construction and barbaric operation, especially when finishing paint construction, must have more than three years of work experience.

5、施工环境:无论封闭底漆、中涂漆、还是面漆,由于胺类固化剂反应一般低于5℃基本不反应,所以涂装环境温度在10℃以上时较佳,如低于这个温度,对涂料则需采取一些改进措施。高湿度也对涂层外观有很大影响,特别要避免在低温高湿环境下施工,所以一般相对湿度小于85%时方能施工。

5. Construction environment: Whether closed primer, intermediate paint or topcoat, because the reaction of amine curing agent is generally lower than 5 C, it is better to apply the environment temperature above 10 C. If it is lower than this temperature, some improvement measures should be taken for the coatings. High humidity also has a great impact on the appearance of the coating, especially to avoid construction in low temperature and high humidity environment, so the general relative humidity is less than 85% before construction. 

辛苦整理!转载请注明来自 http://pengs888.com/show.asp?id=134

你觉得这篇文章怎么样?

0 0
网友评论

管理员

该内容暂无评论

美国网友
在线咨询
微信咨询
联系电话
137-7148-9633
返回顶部